Download

Table of Contents > Activated charcoal filter system (Golf, Eos with engine code CBFA, CCTA, CCTB) > Removing and installing activated charcoal filter

VW Passat B6 Service Manual ➜ Removing and installing activated charcoal filter

CC 2010 ➤ , Eos 2006 ➤ , Golf 2004 ➤ , Golf 2009 ➤ , Passat 2006 ➤ , ...

4-cyl. injection engine (1.8 and 2.0 l engine, chain drive) - Edition 08.2018

20 - 2 Nm

13.4

Removing and installing activated char‐

coal filter

Special tools and workshop equipment required

♦ Engine and gearbox jack - V.A.G 1383 A-

Removing:

– Remove centre and rear silencers.

– Remove heat shield -arrows-.

– Position engine and gearbox jack - V.A.G 1383 A- below rear

axle to support.

– Loosen securing bolts of rear axle -arrows- and unscrew them

approx. 20mm.

– Lower rear axle slowly using engine and gearbox jack -

V.A.G 1383 A- .

414

Rep. gr.20 - Fuel supply system

CC 2010 ➤ , Eos 2006 ➤ , Golf 2004 ➤ , Golf 2009 ➤ , Passat 2006 ➤ , ...

4-cyl. injection engine (1.8 and 2.0 l engine, chain drive) - Edition 08.2018

– Pull off breather lines -A- by pressing release tab.

– Remove bolts -B-.

Note

A reinforcement plate is installed in the Eos. To loosen and tighten

securing bolts -B-, use T-bar and socket 10 mm - 3185- .

– Release retaining tabs -A- using a screwdriver. Turn activated

charcoal filter approx. 90° to right -B- and remove activated

charcoal filter.

Installing:

Installation is carried out in the reverse order. When installing,

note the following:

– Fit breather lines so that they engage audibly.

– Install rear axle ⇒ Running gear; Rep. gr. 42 .

Specified torque

Component

Activated charcoal filter to body

13.5

Removing and installing fuel system di‐

agnostic pump - V144- (Golf)

Removing:

– Remove rear right wheel housing liner ⇒ General body re‐

pairs, exterior; Rep. gr. 66 .

– Pull off breather line -1-.

– Separate electrical connector -2-.

– Pull off breather line -3- by pressing release tab.

– Unscrew nuts -arrows-.

– Detach diagnostic pump with bracket.

Installing:

Installation is carried out in the reverse order. When installing,

note the following:

•

The breather line -3- must engage audibly.

– Install rear right wheel housing liner ⇒ General body repairs,

exterior; Rep. gr. 66 .

Specified torques: ⇒ page 412

13. Activated charcoal filter system (Golf, Eos with engine code CBFA, CCTA, CCTB)

415

reload full screen

Need help?

If after viewing the owner's manual or service manual you still have some unresolved questions about the car VW Passat you can write to us using the link below, describing your problem in detail, we try to answer all questions.

Ask your question on the page - Support!

ALL VW Passat OWNER'S MANUALS

2024 VW Passat Owner's Manual